/ Alpkit Gamma shorting out?
I lent it to my son for his cubs outside meet this week, he came home reporting it had "broken" (kids, don't you just luv 'em and their ability to break all your stuff?). It had new batteries in it so I knew that wasn't the issue. On taking the batteries out (just normal IKEA alkalines) on one there is a noticeable black scorch mark and all three the yellow plastic around the batteries had shrunk exposing some of the metal. I've not seen this before, but can only imagine that it was sudden heat to make the plastic shrivel like that? So a short circuit? There is also some kind of residue or discolouration inside the battery box - again I don't think it was there before. So it seems like something exciting happened in there.
The connections seem damaged but not totally blown now, as it still works sometimes but with a tendency to turn itself off and on in an unhelpful manner. I know lots of people have broken their Gammas physically, but has anyone else seen this? I was wondering if the batteries could have been the problem or something in the battery case that made it short?
I've had batteries do something similar before - the plastic jackets shrank. The weirdest thing, was that these batteries weren't in a device at the time this happened - they were sat on a bed in a hut while I was out for 3 days. They may have got quite cold (sub zero) but they were not exposed to any heat or any obvious method of shorting them. I had no idea what caused it. I returned them to Duracell, who replaced them with no quibble. Is it possible that this is due to faulty batteries?
Sounds like one or more of the batteries has supplied too much current and overheated. The plastic film shrinks with heat and the residue is possibly from one or more of the batteries venting. Cylindrical cells can short internally or at the end caps especially if if abused but it sounds like the fault is more likely in your torch. The other possibility is if there are 3 cells your young lad put one in back to front, I'm guessing it's a modern LED lamp with a switching supply which will still be able to draw a lot of current (more than usual) from that set up overcharging and overheating the reversed cell. The two correct ones would also be heavily loaded and run warm. That wouldn't explain the propensity for turning itself off now though.
Coincidentally, my Gamma head torch went wrong about 2 weeks ago. It was about two years old and like you had been used through 2 winters strapped to my bike helmet, plus plenty of other general outdoor usage. The batteries ran out and when I replaced them, the switch on the rear LED was stuck on flashing mode.
I emailed Alpkit and they got me to sent it back via freepost. As usual very good customer service, they rang me up and told me there was a likely short circuit in the battery compartment, probably caused by water ingress and battery corrosion. They suggested that after use in heavy rain/wet weather, the batteries are removed and battery compartment left open over night to ensure its dry. They knocked 10% off a replacement, which I thought was a very nice gesture as they had no obligation to do so.
My gamma is a bit iffy as well, but for £12.50 it's hardly something I worry too much about. I think it's a dodgy connection around the actual light area, as it only seems to go when I adjust it.
Bit of a mystery, my personal experience with older torches has been after leaving batteries in for a long time without using them something similar has happened. Had you left the torch unused for a while? Sometimes it is just a cheaper brand of battery causes a problem if it leaks.
Drop us an e-mail and I can sort out getting it back to us to have a look at and hopefully repair or help out on a new one -
Elsewhere on the site
F ounded in 1993, Mountain Hardwear are a pretty young mountaineering clothing and equipment manufacturer but are also one of... Read more
On Saturday 13th December Greg Boswell and Guy Robertson kicked off their Scottish winter season early by making the... Read more
The Epicentre Mega Winter Sale starts in store 9am Christmas Eve. We have a great selection of in store only deals from... Read more
With four photos in this week's top ten, and a UKC gallery of stunning images we thought it was time we had a chat with... Read more
This years ROCfest will be slightly different. We've decided to run a Climbing Festival, not just a competition! Over... Read more